Беспилотный вертолет Boeing A160 Hummingbird: разработка и испытания

Unmanned aerial vehicle by Boeing

The Boeing A160 Hummingbird (military designation: YMQ 18A) is an unmanned aerial vehicle (UAV) helicopter. Its design incorporates many new technologies never before used in helicopters, allowing for greater endurance and altitude than any helicopter currently in operation. The development of Hummingbird was begun for DARPA by Frontier Aircraft in 1998. From 2003 both the US Army and the US Navy also shared in funding the project. In May 2004, the company was acquired by Boeing and became integrated into Boeing Phantom Works and then into the Advanced Systems group of Boeing Integrated Defense Systems. The A160 continued with developmental flight tests in 2010, but test flights had already demonstrated greater endurance, higher altitudes, more extensive autonomy, and greater payload. The program had ambitious goals of a 2500 mile (4023 km) range, 24 hour endurance, and 30000 feet (9144 m) altitude. Flights were largely autonomous, with the aircraft making its own decisions about how to fly itself so as to meet certain objectives, rather than relying on real time human control. The A160 achieved maximum speeds of over , though endurance and altitude were its goals, not speed. The aircraft measures 35 feet (11 m) from nose to tail and has a rotor diameter of 36 feet (11 m). The project was abandoned by the US Army in December 2012.

During the initial development of the A160 airframe and rotor system in 1999–2000, Frontier Systems simultaneously designed the Maverick vertical take off and landing (VTOL) UAV as a testbed for avionics, software and flight control systems. The Maverick was a highly modified version of the Robinson R22 light civilian helicopter. By using a proven helicopter airframe, engineers were able to focus on developing systems that could be later transferred to the A160. The Maverick program began in 1998, with the first flight taking place less than a year later in 1999. Although the R22 was a two seat manned helicopter in its original configuration, the Maverick was significant for never having used a "safety pilot" (a human pilot riding on board and capable of recovering the aircraft in the event of a failure of the unmanned flight control system). Since much of the software and avionics systems were shared between Maverick and A160, Maverick remained in service long after A160 began flight operations. After acquiring Frontier Systems in 2004, Boeing halted most development of Maverick but it continued flying as a training asset and for reducing risk in technology development for the A160. Since being acquired by the military, most Maverick operations are unpublicized. March 2006 saw the completion of the Software Enabled Control program sponsored by the Defense Advanced Research Projects Agency(DARPA). With the help of researchers from UC Berkeley, MIT, and Georgia Tech, Boeing developed a variant of its Maverick UAV platform which became known as the Renegade UAV. This aircraft successfully performed various maneuvers and flew routes without real time human input.

The development program for the A160 began when DARPA awarded a 30 month technology demonstration contract to San Diego based Frontier Systems in March 1998, owned by UAV pioneer Abe Karem. In June 1999, Frontier tested the autonomous flight control system with the Maverick A, a modified Robinson R22. This test bed was lost during a crash in 2000, after having flown for 215 hours. The first prototype, a three blade A160, demonstrated a brief hover on December 7, 2001 and performed its first forward flight on January 29, 2002. A four blade version of the A160 flew in November 2002 using a Subaru four cylinder engine, and later a six cylinder piston engine. Frontier Systems was awarded a contract for four more A160s in October 2003. A total of three vehicles were produced by Frontier Systems. Vehicles 1 and 3 were lost in crashes. Frontier began a planned KW600 Diesel engine for the vehicle, but never completed it. A Diesel engine would have nearly doubled the vehicle endurance due to lower fuel consumption. Frontier Aircraft, and later Boeing, carried out the A160 program as part of a series of contracts with Defense Advanced Research Projects Agency (DARPA), the United States Army, and the United States Navy from 2003. In September 2003, DARPA awarded Frontier a $75 million contract for the design, development and testing of four A160s. using a two speed transmission to optimize efficiency at different speeds and altitudes, a technique called "optimum speed rotor technology", invented by Abe Karem. It is primarily because of these features that the Hummingbird can fly with less power and thus use less fuel than comparable conventional helicopters, On September 20, 2004, the Hummingbird made its first flight since Boeing took over the program the previous May. The test program operated from the Southern California Logistics Airport near Victorville, California. In August 2005, the Hummingbird was flown around Victorville in a 1,200 mile course at 60 knots and 4000 feet, one of the longest helicopter flights ever. A mechanical failure caused the helicopter to crash near the end of the flight and flight testing continued some months later after the crash investigation was concluded. On November 30, 2005, the aircraft successfully completed its first flight with a new 290 kW (390 hp) 6 cylinder gasoline powered piston engine, hovering about the airfield for about half an hour. It was flown for 8 hours on September 27, 2007 while carrying a 1,000 pound payload. On October 12 it flew for 12 hours while carrying a 500 pound payload, simulating a multi sensor military reconnaissance mission. This latter flight used up less than 60% of the Hummingbird's maximum fuel load. On December 10, 2007, one of the A160T prototypes crashed during a flight test at Boeing Advanced Systems' test facility in Victorville. A Boeing investigation determined the incident was caused when sensor data stopped being updated to the flight computer: with the feedback loop for the control system effectively cut, the helicopter "departed controlled flight and impacted the ground at a near vertical angle." Much of the forensic evidence was burned in the post crash fire. A number of potential areas that could have caused the software feedback update thread to stop were found, and those known problem areas were addressed and flight testing resumed on March 26, 2008. On May 9, 2008, at Yuma Proving Ground in Arizona, the A160T demonstrated its ability to hover out of ground effect (HOGE) at 15,000 feet to meet its DARPA milestone. It then surpassed the milestone during the same flight by repeating the HOGE at 20,000 feet altitude. A week later, starting the night of May 14, the A160T demonstrated its un refueled endurance capabilities with an 18.7 hour flight, landing with over 90 minutes of fuel still on board. This was recognized as the longest un refueled flight of any rotorcraft, and the Fédération Aéronautique Internationale (FAI) awarded Boeing the official endurance record in the 500 kg to 2,500 kg autonomously controlled UAV class for the flight. Earlier, in May 2004, the U. S. Army Communications Electronics Command awarded Syracuse Research Corp. a $13.3 million contract for the ultra high frequency, foliage penetrating, real time moving target indicator/synthetic aperture radar for use in the A160. The A160T successfully completed the re supply demonstration in early March 2010. In December 2010, NAVAIR awarded a $29.9 million contract to Boeing for two A160Ts and control systems. Kaman received a similar contract worth $46M. NAVAIR issued a stop work order on the A160 in December 2011, before a Quick Reaction Assessment. The K MAX was eventually chosen over the A160T for the unmanned resupply role by the Marines, and was sent to Afghanistan in 2011. On July 28, 2010 an A160T crashed at Southern California Logistics Airport. It autorotated to the ground then rolled on its side. In August 2010, the A160T underwent jungle test flights in Belize for the U. S. Special Operations Command. Two airframes were involved in tests of the ability of DARPA FORESTER foliage penetrating radar to penetrate jungle cover. The tests were stopped one week early when one aircraft crashed on September 4, 2010 at the Central Farm airfield in Cayo, Belize as the Special Operations Command was turning over its A160s to the Army in 2011. A further crash caused by vibration occurred at Victorville on 17 April 2012, damaging the ARGUS sensor and the aircraft.

The A160 was to be deployed to Afghanistan with the ARGUS IS camera in June 2012. But just before deployment, the Army issued a stop work order to Boeing because the aircraft had a high "probability of continued technical and schedule delays," and costs and risks had "increased so significantly that program continuation was no longer in the best interest of the government." Vibration was among the issues.